Servicio de HVAC en Fultondale, Alabama

Control board replacement, Walker Chapel rebuild home

“Post-April-2011 rebuild with a 2013 Goodman 3-ton heat pump. Thermostat dark after a lightning event. Control board fried, transformer intact. Installed whole-home surge protector at the panel and a dedicated HVAC surge protector at the outdoor disconnect before leaving.”

— Nota de servicio, Fultondale

Blower motor bearing failure, Carson Road townhome

“Whirring noise from the air handler over several weeks. Indoor blower bearings dry and the capacitor was weak. Replaced the X13 motor assembly with an OEM part, tested static pressure at 0.6 in. w.c. across the coil — within spec — and cycled the system through full cooling.”

— Nota de servicio, Fultondale

Duct leak repair, Highway 31 corridor ranch

“Power bill doubled over the previous summer. Pressure-tested the duct system with a blower-door assist and found a 22% leakage rate — most of it at the plenum-to-takeoff joints in the attic. Sealed with water-based mastic and reinforced with foil tape. Retested at 6% post-repair.”

— Nota de servicio, Fultondale

Oversized system diagnosis, Black Creek Trail rebuild

“Homeowner complained of a clammy feel at 76°F. Manual J on the rebuilt envelope came back at 2.2 tons; the installed unit was 3 tons. Short-term fix was slowing the blower to the low-CFM tap and adding a dedicated condensate dehumidifier. Long-term recommendation noted in writing for eventual replacement.”

— Nota de servicio, Fultondale

Condensate float switch trip, Walker Chapel two-story

“System shut down on the hottest afternoon of the week. Primary drain clogged with biofilm. Cleared the line back to daylight, flushed with a condensate tablet, and installed a wet-switch on the secondary pan. Homeowner got fifteen minutes of training on annual drain treatment.”

— Nota de servicio, Fultondale

Gas furnace heat exchanger inspection, older pre-2011 home

“Twenty-four-year-old 80% furnace pre-heating-season. Camera inspection of the heat exchanger showed no cracks, but the inducer motor was drawing high amps and the flue collector was rusted. Inducer and collector box replaced, combustion analysis clean at 6.8% O₂ and 28 ppm CO.”

— Nota de servicio, Fultondale

Surge protection retrofit, I-65 corridor

“After a neighbor lost a thermostat to lightning, homeowner asked for protection. Installed a panel-level surge protector (SPD Type 2), plus a dedicated HVAC surge protector at the outdoor disconnect. Documented the joule rating and manufacturer warranty connect-equipment coverage.”

— Nota de servicio, Fultondale